定制的無菌工作服的清洗：

　　Cleaning of customized sterile workwear:

　　1.每周一，操作人員會將更換后的無菌工作服連同專用的清潔儲物袋一起，用密閉的不銹鋼容器帶出更衣室，送到室。

　　1. Every Monday, the operator will take the replaced sterile work clothes along with a dedicated cleaning storage bag out of the changing room in a sealed stainless steel container and send them to the disinfection room.

　　2.洗衣工將工作服放入室的洗衣機中，每次清洗不超過五套工作服，使用30-50毫升洗衣液，并向洗衣桶中加入三分之二的純凈水。

　　2. The laundry worker places the work clothes into the washing machine in the disinfection room, cleaning no more than five sets of work clothes at a time, using 30-50 milliliters of laundry detergent, and adding two-thirds of pure water to the washing bucket.

　　3.按《洗衣機標準操作規程》設置洗衣程序(設置為“正?！?。清洗工作服30分鐘，清洗后放出洗滌液；用純凈水沖洗，直到?jīng)_洗水中沒有泡沫，然后甩干。

　　3. Set the washing program according to the "Standard Operating Procedures for Washing Machines" (set to "Normal"). Clean work clothes for 30 minutes, then release the detergent after cleaning; Rinse with purified water until there is no foam in the rinsing water, and then dry it.

　　4.應根據無菌工作服的清潔方法，通過清洗、干燥和烘干來清潔無菌工作的儲存袋。

　　4. The storage bags for sterile work should be cleaned by washing, drying, and oven drying according to the cleaning method of sterile work clothes.

　　5.室整理烘干好的工作服，按照數量一件一件的裝入衣袋。裝有無菌工作服的袋子應由耐高溫材料制成。

　　5. Organize and dry the work clothes in the disinfection room, and put them into pockets one by one according to the quantity. The bag containing sterile work clothes should be made of high-temperature resistant materials.

　　定制的無菌工作服的：

　　Sterilization of customized sterile workwear:

　　6.11萬級無菌工作服在使用時，應進行。洗衣工將內部裝有無菌工作服的耐高溫布袋放入密封袋中，通過傳送窗傳送到十萬級洗烘瓶室。操作人員用純蒸汽在121℃下30分鐘。

　　Grade 61100 sterile workwear should be disinfected during use. The laundry worker places the high-temperature resistant cloth bag containing sterile work clothes inside into a sealed bag and transports it through the transfer window to the 100000 level washing and drying bottle disinfection room. The disinfection operator disinfects with pure steam at 121 ℃ for 30 minutes.

　　6.2洗衣工按《人員進入無菌潔凈室(區)凈化規程》進入室，取出器內已的無菌物品，存放在無菌區更衣室內保管。

　　6.2 Laundry workers shall enter the sterilization room in accordance with the "Personnel Entry into Aseptic Clean Room (Area) Purification Regulations", take out sterilized sterile items from the sterilizer, and store them in the sterile area changing room for safekeeping.

　　7.洗衣工應保留每天清洗、和分發已清洗和工作服的記錄。做好洗衣設備和設備的設備運行記錄。

　　7. Laundry workers should keep records of daily cleaning, disinfection, and distribution of washed and disinfected work clothes. Keep operation records of laundry and disinfection equipment.

　　8.注意事項：無菌工作服的清洗整理應在上午完成，以免與下午清洗容器重疊。

　　8. Precautions: The cleaning and organization of sterile work clothes should be completed in the morning to avoid overlapping with the cleaning containers in the afternoon.

　　潔凈區有穿不是潔凈服的人，潔凈服應在相應等級的潔凈環境中定期清洗烘干。

　　If there are people wearing non clean clothes in the clean area, the clean clothes should be regularly cleaned and dried in a clean environment of the corresponding level.

　　工人不允許帶回家，在戶外晾干。同時還考慮了水質對潔凈服清潔效果的影響。對于水質差、水質不穩定、含鹽、機械雜質、微生物高的水，不能直接用于清洗潔凈服。清洗潔凈工作服應使用純凈水。

　　Workers are not allowed to bring it home and dry it outdoors. At the same time, the impact of water quality on the cleaning effect of clean clothing was also considered. For water with poor water quality, unstable water quality, high salt content, mechanical impurities, and microorganisms, it cannot be directly used for cleaning clean clothes. Clean work clothes should be washed with pure water.

　　工人的工作服應每天下班后用紫外線一次，而不是與日常衣物存放在同一地方。紫外線燈30分鐘，機器：壓力蒸汽121℃30分鐘。

　　Workers' work clothes should be disinfected with ultraviolet light once a day after work, instead of being stored in the same place as daily clothing. UV lamp disinfection for 30 minutes, machine disinfection: pressure steam disinfection at 121 ℃ for 30 minutes.